歡迎訪問濟南大黃蜂工程機械有限公司官方網站!

冷再生機租賃

全國施工租賃熱線

全國施工租賃熱線

18366127778

您現在所在的位置 :首頁 - 新聞中心 > 行業資訊 >

行業資訊

information

全國施工租賃熱線

18366127778

山東大黃蜂工程機械有限公司

聯系電話:18366127778

公司地址:濟南市槐蔭區經一路273號群盛華城2號樓1-404

行業資訊

瀝青撒布車日常操作應該注意哪些事項?

來源:http://www.aluminiumcanisters.com/ 日期:2021-07-05
瀝青撒布車是道路建設中不可或缺的工程機械。但我們在選擇瀝青撒布車還是需要注意以下幾個問題。
Asphalt spreader is an indispensable construction machinery in road construction. But we still need to pay attention to the following problems in the selection of asphalt spreader.
在公路施工技術規范中,瀝青撒布車的定額都是有規定的。瀝青泵的流量與其轉速不同也是有影響的,對于專業發動機驅動瀝青泵的瀝青撒布車來說,其轉速和車速都是可以由發動機調整的。因此,二者的緊密配合,做出合理的調整,才能達到良好的灑布效果。所以,我們在選定瀝青撒布車時,不要只看它的外在質量,還要根據瀝青撒布車的各種性能,如瀝青泵的流量,以及車速是否吻合。
In the technical specifications of highway construction, the quota of asphalt spreader is stipulated. The flow rate of asphalt pump and its speed also have an impact. For the asphalt spreader with professional engine driven asphalt pump, its speed and speed can be adjusted by the engine. Therefore, the close cooperation of the two, make reasonable adjustment, in order to achieve good spraying effect. Therefore, when we select the asphalt spreader, we should not only look at its external quality, but also according to its various performance, such as the flow of the asphalt pump, and whether the speed is consistent.
                    水泥撒布車租賃
瀝青撒布車日常操作應該注意哪些事項?這才是關鍵!
What should be paid attention to in daily operation of asphalt spreader? That's the key!
1、滿載的撒布車在行駛過程中,應采用中速行駛,遇有彎道、下坡路時應提前減速,盡量避免緊急制動;這是因為瀝青罐體內的瀝青為液態流體狀,行駛過程中其車輛不穩定,容易偏離,在上述情況下更加嚴重。
1. When the spreader with full load is running, it should run at medium speed. In case of curve or downhill, it should slow down in advance to avoid emergency braking as far as possible; This is because the asphalt in the asphalt tank is liquid fluid, the vehicle is unstable and easy to deviate during driving, which is more serious in the above cases.
2、檢查機械、灑布裝置及防護、防火設備是否齊全。采用固定式噴燈向瀝青箱的火管加熱時,應先打開瀝青箱上的煙囪口,并在液態瀝青淹沒火管后,方可點燃噴燈。加熱噴燈的火焰過大或擴散蔓延時應立即關閉噴燈,待多余的燃油燒盡后再行使用。噴燈使用前,應先封閉吸油管及進料口,手提噴燈點燃后不得接近易燃品;行駛時嚴禁使用加熱系統。
2. Check whether the machinery, spraying device, protection and fire prevention equipment are complete. When the fixed spray lamp is used to heat the fire pipe of the asphalt box, the chimney opening on the asphalt box should be opened first, and the spray lamp can be ignited only after the liquid asphalt submerges the fire pipe. When the flame of the heating blowtorch is too large or spread, the blowtorch should be turned off immediately, and then it can be used after the excess fuel is burned out. Before using the blowtorch, the oil suction pipe and the feeding port should be closed first, and the portable blowtorch should not be close to the inflammables after being ignited; Do not use heating system when driving.
3、瀝青撒布車駕駛員與機上操作人員應密切配合,操作人員應注意自身的安全。作業時在噴灑瀝青方向10m以內不得有人停留,以免造成事故。
3. The driver of asphalt spreader should cooperate closely with the operator on the machine, and the operator should pay attention to his own safety. No one is allowed to stay within 10m in the direction of spraying asphalt to avoid accidents.
  • 上一條:就地冷再生機,破行業格局需技術突破!
  • 下一條:冷再生技術存在的問題和發展方向!
  • 相關產品:

    亚洲国产精品一区二区手机

    <pre id="sppjn"></pre>